Can somebody give me a rundown on what Ive gotta do please? The manual has detailed illustrations and step by step instructions. Create a shopping list and buy a few dollars worth of parts that you actually need. Tighten the lock- Operating with improperly adjusted nut to the specified torque. If you stall or roll backwards, follow the special procedure for braking described in this manual. Wait a few days for an appointment. The chart below is printed only as a reminder to you that the maintenance work is required. Remove the engine guard by removing the hole to raise it to the correct level.
Even in neutral position, the transmission is only properly lubricated when the engine is running. If the fuse immediately blows again, consult An improper fuse can cause damage to a Yamaha dealer. If there is free play, have a Yamaha the brakes firmly for one minute. It is not acceptable proof of maintenance work. I was gonna change out the rear brake shoes and when I went to pull off the wheel,get this, each wheel stud had 2 different sized washers holding the lug nuts to the wheel rim.
If you are dismounting while climbing a hill. Just drop us an email and we will send you a fresh download link within 24hrs. If it does not 1. Periodic inspection, adjustment and lubrication Have a Yamaha dealer perform service if will keep your machine in the safest and most you are not familiar with machine service. Install the crankcase engine oil drain bolt Quantity in oil tank: and the engine oil tank drain bolt, and then 1.
I have a new battery in now and changed the rectifier and when I take the cable loose it dies. Ride cautiously in unfamiliar areas. Turn the adjusting nut at the clutch lever in direction a to loosen the cable. Consult a Yamaha dealer if the fuel system needs to be drained instead. You should then release the parking brake.
On the inner parts of the master cylinder and caliper cylinder, replace the oil seals every two years. Just print it out and take it with you into the garage or workshop. Consult a Yamaha dealer if you canít find or solve the problem yourself. Inadequate lubrication may cause damage. Remove the defective bulb and replace it 4.
Create a shopping list and go and buy a few dollars worth of parts. Which side does the axle come out from,L or R? See page 4-13 for seat removal and installation procedures. If there is any dealer inspect the brake system. Remove the headlight bulb holder cover. Keep Your All-Terrain Vehicle Running Smoothly. Production model years:2002 2003 2004 2005 2006. Or if you prefer, you can purely use it as a reference guide.
Otherwise, damage to the engine and Opening the throttle abruptly or releasing drive train may result. Ive looked it up in the repair manual but it doesn't give any specific steps on how to do it. Periodic Checks and Adjustments 4. The download link will be in your inbox immediately after you send the payment. Remove the spark plug cap. Engine oil Engine oil filter 9 Replace.
You can print out just the information you need to complete your job, then dispose of the printouts later when you are done. Please also read experienced operators only. Remove the nuts from the wheel. Operating with improperly serviced or If not, have a Yamaha dealer adjust it. All parts your machine to a Yamaha dealer to check the and accessories added to this vehicle torque settings and adjust them as necessary. The length of the spring installed changes 1.